R&D FOODS
SCORE: 32 POINTSThursday, April 14, 2022
Violations Cited
06D
Food Contact Surfaces Not Properly Sanitized
Food contact surface not properly washed, rinsed and sanitized after each use and following any activity when contamination may have occurred.
BACTERIAL BUILDUP: Unsanitized surfaces harbor millions of bacteria within hours. Cross-contamination affects all food prepared on surface. Major cause of multi-victim outbreaks. Cutting boards can contain 200x more bacteria than toilet seats.
Clean and sanitize ALL food contact surfaces: After each use, Between different food types, Every 4 hours in continuous use, When contaminated. Use proper concentration sanitizer (50-100ppm chlorine, 200-400ppm quat). Air dry. Test sanitizer every 2 hours.
10F
Non-food Contact Surfaces Not Clean
Non-food contact surface improperly constructed. Unacceptable material used. Non-food contact surface or equipment improperly maintained and/or not properly sealed, raised, spaced or movable to allow accessibility for cleaning on all sides, above and underneath the unit.
INDIRECT CONTAMINATION: Dirty non-food surfaces harbor pests and bacteria. Employees touch these surfaces then food. Accumulation attracts roaches and rodents. Creates reservoir of contamination that spreads throughout facility.
Clean all non-food surfaces regularly: Walls, ceilings, floors daily in food areas, Equipment exteriors, Storage shelves, Light fixtures monthly. Seal cracks. Repair damaged surfaces. Maintain cleaning schedule. Assign responsibilities.
06C
Food not protected from contamination
Food not protected from potential source of contamination during storage, preparation, transportation, display or service.
Unprotected food exposed to bacteria, viruses, chemicals, and physical contaminants
Cover all food; store 6 inches off floor; protect from customer contamination; use sneeze guards
02G
Cold TCS Food Held Above 41°F
Cold food item held above 41º F (smoked fish and reduced oxygen packaged foods above 38 ºF) except during necessary preparation.
DANGER ZONE GROWTH: Between 41-70°F, E. coli doubles every 30 minutes. Salmonella doubles every 20 minutes at 70-90°F. After just 4 hours above 41°F, bacteria levels can cause severe illness including bloody diarrhea, kidney failure (E. coli), and typhoid fever (Salmonella).
Keep all cold TCS foods at 41°F or below (smoked fish 38°F, shell eggs 45°F). Monitor with calibrated thermometer every 2-4 hours. Ice baths must surround container to food level. Repair refrigeration immediately. DISCARD foods above 41°F for over 4 hours.
05D
Hand Washing Facility Not Properly Equipped
Hand washing facility not provided in or near food preparation area and toilet room. Hot and cold running water at adequate pressure to enable cleanliness of employees not provided at facility. Soap and an acceptable hand-drying device not provided.
HEALTH HAZARD: This critical violation creates immediate risk of foodborne illness. Studies link Hand Washing Facility Not Properly Equip to bacterial contamination and outbreak events. Must be corrected immediately to protect public health.
Provide immediately at ALL handwash sinks: Hot water (100-120°F), Soap in dispensers, Paper towels or air dryers, Trash receptacles, Signage, Keep accessible at all times. Check supplies hourly. Assign staff to monitor and restock.
Violations were cited in the following area(s).